Although there are many reasons for the motor being burned, the proper use of the pump is one of the important reasons.
When using a water pump, after the power is turned on, carefully observe the operation of the water pump. The water should be continuous and uniform, and the pump can be used without vibration and noise. If the machine suddenly shuts down during operation, immediately disconnect the power supply and check its cause. The interval between two start-up times of the pump shall be limited to the total return of the water in the pump. If it starts too early, the motor will be burned due to excessive resistance and water hammer in the water pipe. In addition, if the pump is installed in the well, pay attention to the flow of the pump should be consistent with the normal amount of water out of the well, otherwise it will cause the empty machine to run, burn the motor.
In order to ensure the normal operation of the pump, it should also be checked before use.
1. Use a universal meter to check if the pump motor windings are open circuited. Its insulation can be used for 500 volt megohmmeter measurements. When the insulation resistance is lower than 0.5 megohms, the pump cannot be used.
2, remove the filter, turn the pump shaft is flexible, if not flexible, should be adjusted before use.
3. Whether the fuse capacity of the gate is suitable or not, other conductors cannot be used instead of the fuse.
4. Turn on the power and check whether the impeller is running normally (the power on time must not exceed 3 to 5 seconds, otherwise it is easy to burn out the motor).
Wanyuan Garlic Foods is a manufacturer and exporter of Vacuum fried,Fried and Dehydrated vegetables since 2005.We have got a patent for VF products.
The ingredients of Vacuum Fried Mixed Vegetables can be customerized, it can be eat directly as snacks.
Vacuum Fried Mixed Vegetables
Vacuum Fried Mixed Vegetables
Huaiyang County Wanyuan Garlic Foods Processing Industries Co.,Ltd , https://www.wanyuangarlicfood.com